Iec 62133 Test Report, The IEC/EN 62133 Test Report Seal of NCT:_____________ The results detailed in this test report relate only to the specific sample(s) tested. issued by an NCB in accordance with IECEE To address safety standards for lithium ion battery products, International Electrotechnical Commission (IEC) 62133- was introduced. This report is not valid as a CB Test Report If this Test Report Form is used by non-IECEE members, the IECEE/IEC logo and the reference to the CB Scheme procedure shall be removed. the IECEE is acknowledged as copyright owner and source of the material. This report is not valid as a CB Test Report unless signed What's IEC 62133 Certification of Lithium-Ion Battery? IEC62133 Certification, Li-ion battery IEC 62133 test report, lithium ion polymer batteries, lithium ion cells, China polymer li-ion battery manufacturer Summary of testing: The sample(s) tested complies with the requirements of IEC 62133-2: 2017. This report is not valid as a CB Test Report The IEC/EN 62133 Test Report ensures lithium battery safety for CE certification. IECEE takes no responsibility for and will not assume liability /IEC logo and the r d as a CB Test Report unless 国际互认 检测 Test Report issued under the responsibility of: TESTING CNAS L6165 TEST REPORT IEC 62133-2 No decision rule is specified by the IEC standard, when comparing the measurement result with the applicable limit according to the specification in that standard. This report is not to be reproduced except in full, without written approval from NCT Testing ced material due to its placement and context. This document cannot be reproduced except in If this Test Report Form is used by non-IECEE members, the IECEE/IEC logo and the reference to the CB Scheme procedure shall be removed. : of issue IEC 62133-2 test report is the standard for the safety of rechargeable batteries. IEC 62133‑2 — IEC Webstore (IEC) — Must for portable packs. Our guide covers requirements, testing process, sample preparation, and common pitfalls to avoid. It covers tests like short circuit, crush, and overcharging. Accepted in over 50 countries/regions, enabling direct conversion Laboratory testing: Conduct a full set of safety tests in accordance with standard requirements. This report is not valid as a CB Test Report unless signed IEC 62133 2nd Edition: All you need to know about the new standard Laurie Florence Principal Engineer Batteries, Fuel Cells & Capacitors IEC 62133-2 testrapport behandelt algemene vereisten die van toepassing zijn op alle soorten batterijen die onder de norm vallen. s signed by an approved IECEE Testing Laboratory and Prüfverfahren aus einer Hand Bei uns erhalten Sie alle notwendigen Tests für die IEC 62133-2 Zertifizierung an einem Ort. This report is not valid as a CB Test Report unless signed by an approved IECEE Testing Laboratory and appended to a CB Test Certificate issued by an NCB in accordance with IECEE 02. This report shall not be reproduced, except in full, without the written approval of the Issuing Shenzhen TCT Testing If this Test Report Form is used by non-IECEE members, the IECEE/IEC logo and the reference to the CB Scheme procedure shall be removed. 3 UND IEC 62133 WICHTIG? Lithium-Ionen-Batterien sind mittlerweile aus batteriebetriebenen Geräten des täglichen We certify your batteries according to IEC 62133-2: Complete test coverage Individual test procedures Fast market access Find out more now! Droits de reproduction réservés. 1 Vibration 7. Part 2 of it covers requirements for lithium-ion batteries. This report is not valid as a CB Test Report unless signed What is IEC62133? Crucial for product safety standards, this article explores its significance, testing procedures, covered products, and FAQs. General YAT-SEN SCIENTIFIC INDUSTRIAL PARK, WUQING DISTRICT,TIANJIN, P. in t is If this Test Report Form is used by non-IECEE members, the IECEE/IEC logo and the reference to the CB Scheme procedure shall be removed. The decisions on conformity are made If this Test Report Form is used by non-IECEE members, the IECEE/IEC logo and the reference to the CB Scheme procedure shall be removed. The test results presented in this report relate only to the object tested. 3. TEST REPORT IEC 62133-2 Secondary cells and batteries containing alkaline or other non-acid electrolytes – Safety requirements for portable sealed secondary cells, and for batteries made from TEST REPORT IEC 62133-2 Secondary cells and batteries containing alkaline or other non-acid electrolytes – Safety requirements for portable sealed secondary cells, and for batteries made from This report is not valid as a CB Test Report unless signed by an approved CB Testing Laboratory and appended to a CB Test Certificate issued by an NCB in accordance with IECEE 02. IECEE Test Report Form 62133-2A IECEE TRF 62133-2A:2017 This Test Report Form applies to: IEC 62133-2:2017 What is the Lithium Battery IEC 62133 Since its first publication in 2002, the IEC 62133 series of standards has enabled international harmonization of safety This report is not valid as a CB Test Report unless signed by an approved IECEE Testing Laboratory and appended to a CB Test Certificate issued by an NCB in accordance with IECEE 02. Dit omvat vereisten voor materialen, ontwerp, constructie, markering, 7. This report is not valid as a CB Test Report unless signed IEC 62133-2:2017 specifies requirements and tests for the safe operation of portable sealed secondary lithium cells and batteries containing non-acid IEC 62133:2012 specifies requirements and tests for the safe operation of portable sealed secondary cells and batteries (other than button) containing alkaline or Test conclusion: The Li-ion Battery PACK submitted by Quanzhou KAILI Electronics Co. This document cannot be reproduced except in full, without The uncertainties of measurement are calculated by the laboratory based on application of criteria given by OD-5014 for test equipment and application of test methods, decision sheets and operational This report is not valid as a CB Test Report unless signed by an approved IECEE Testing Laboratory and appended to a CB Test Certificate issued by an NCB in accordance with Complete guide to IEC 62133: global safety standard for rechargeable batteries & power banks. , Ltd. General Testing location: All tests as described in Test Case and Measurement Sections were performed at the laboratory described on page 1. General TEST REPORT IEC 62133-1 Secondary cells and batteries containing alkaline or other non-acid electrolytes - Safety requirements for portable sealed secondary cells, and for batteries made from IEC 62133-1:2017 specifies requirements and tests for the safe operation of portable sealed secondary nickel cells and batteries containing alkaline . This report is not valid as a CB Test Report unless signed The sample(s) tested complies with the requirements of EN 62133-2:2017 When determining the test conclusion, the Measurement Uncertainty of test has been considered. . Teil 2 davon behandelt Anforderungen an Lithium-Ionen-Batterien. CHINA Additional Information: Additionally evaluated to EN 62133-2:2017 Tests performed (name of test and test clause): Tests are made with the number of samples specified in Table 2 of IEC 62133: 2012 (Second Edition). Summary of testing: The sample(s) tested complies with the requirements of IEC 62133-2:2017 When IECEE Test Report Form 62133-2C IECEE TRF 62133-2C:2025 This Test Report Form applies to: IEC 62133-2:2017, IEC 62133-2:2017/AMD1:2021 TEST REPORT IEC 62133 de from them, for use in portable application Report Number. TUV SUD's lithium-ion battery testing capabilities ensures the safety This report is not valid as a CB Test Report unless signed by an approved IECEE Testing Laboratory and appended to a CB Test Certificate issued by an NCB in accordance with IECEE 02. 8 Mechanical tests (batteries) 7. This report is not valid as a CB Test Report unless signed This report is not valid as a CB Test Report unless signed by an approved CB Testing Laboratory and appended to a CB Test Certificate issued by an NCB in accordance with IECEE 02. General Der Prüfbericht IEC 62133-2 ist der Standard für die Sicherheit von wiederaufladbaren Batterien. GB 31241 / IEC 62133-2: Safety standard for internal lithium-ion cells and battery packs, covering overcharge, short circuit, crush, drop, thermal abuse, and other extreme conditions. Tests are made with the number of cells and batteries specified in IEC 62133-2: 2017 Table 1. EN 62133-2 includes warning labels and testing requirements for coin-cell lithium batteries and small batteries. JJR Lab provides testing services for Provide certificate PDF, certificate number, issue date, and test lab contact. If this Test Report Form is used by non-IECEE members, the IECEE/IEC logo and the reference to the CB Scheme procedure shall be removed. When determining the test conclusion, the Measurement Uncertainty of test has been considered. Report issuance: Issue the IEC 62133 test report upon successful completion of tests. : of issue Therefore, in lieu of a CTL decision to the contrary, either a CB Scheme certificate to IEC 62281, a test report from an ISO 17025 accredited laboratory, OR a report with evidence of equipment calibration, Based on IEC 62133 (portable secondary cells/batteries), IEC 62619 (stationary batteries), IEC 62933 (battery energy storage systems). It includes details on test setup, dimensions, testing Unless otherwise stated the results shown in this test report refer only to the sample(s) tested and such sample(s) are retained for 30 days only. General If this Test Report Form is used by non-IECEE members, the IECEE/IEC logo and the reference to the CB Scheme procedure shall be removed. Test Timeline Performs testing and approval of IEC ANSI/UL CSA 62133 2nd Edition and IEC 62133-2 1st Edition for portable sealed secondary cells. R. This report is not valid as a CB Test Report TEST REPORT IEC 62133 Secondary cells and batteries containing alkaline or other non-acid electrolytes Safety requirements for portable sealed secondary cells, and for batteries made The uncertainties of measurement are calculated by the laboratory based on application of criteria given by OD-5014 for test equipment and application of test methods, decision sheets and operational 中国认可 Test Report issued under the responsibility of: 国际互认 检测 TESTING CNAS L6165 TEST REPORT IEC 62133-2 Intertek can help bring your lithium ion battery products into global markets with testing services to IEC 62133 requirements. 8. 2101 & 2201, Zhenchang Factory, Renshan TEST REPORT IEC 62133-2 Secondary cells and batteries containing alkaline or other non-acid electrolytes – Safety requirements for portable sealed secondary cells, and for batteries made from This report is not valid as a CB Test Report unless signed by an approved CB Testing Laboratory and appended to a CB Test Certificate issued by an NCB in accordance with IECEE 02. IECEE Test Report Form 62133-2C IECEE TRF 62133-2C:2025 This Test Report Form applies to: IEC 62133-2:2017, IEC 62133-2:2017/AMD1:2021 TEST REPORT IEC 62133-2 Secondary cells and batteries containing alkaline or other non-acid electrolytes – Safety requirements for portable sealed secondary cells, and for batteries made from Unless otherwise stated the results shown in this test report refer only to the sample(s) tested and such sample(s) are retained for 30 days only. IEC Guide 115 provides guidance on the application of measurement uncertainty principles and applying the decision rule when reporting test results within IECEE scheme, noting that the reporting of the IEC Guide 115 provides guidance on the application of measurement uncertainty principles and applying the decision rule when reporting test results within IECEE scheme, noting that the reporting of the IEC 62133: 2012 Secondary cells and batteries containing alkaline or other non-acid electrolytes Safety requirements for portable sealed secondary cells, and for batteries made from them, for use in The purpose of this testing is to conduct a comprehensive evaluation of the performance and safety of lithium batteries to ensure compliance with iec 62133 standards. IEC 62133-2 Secondary cells and batteries containing alkaline or other non-acid electrolytes – Safety requirements for portable sealed secondary cells, and for batteries made from them, for TEST REPORT IEC 62133, First Edition Secondary cells and batteries containing alkaline or other non-acid electrolytes – This report provides the experimental procedures for performing the forced internal short-circuit test as specified in IEC 62133:2012. Remark: If this Test Report Form is used by non-IECEE members, the IECEE/IEC logo and the reference to the CB Scheme procedure shall be removed. Covers test items, process, cost, timeline, FAQs & one-stop CB certification solution. Unser modernes Prüflabor führt WARUM SIND PRÜFUNGEN NACH UN 38. Provide test report ID, sample SKUs, and lab If this Test Report Form is used by non-IECEE members, the IECEE/IEC logo and the reference to the CB Scheme procedure shall be removed. s a CB Test Report unless signed by an approved IECEE If this Test Repott Form is used by non-IECEE members, the IECEE/IEC logo and the reference to the CB Scheme procedure shall be removed. If this Test Report Form is used by non-IECEE members, the IECEE/IEC logo and the referen. This report is not valid as a CB Test Report unless signed This report is not valid as a CB Test Report unless signed by an approved IECEE Testing Laboratory and appended to a CB Test Certificate issued by an NCB in accordance with IECEE 02. Das SGS Battery Test House führt Prüfungen und CB-Zertifizierung nach IEC 62133 schnell und professionell durch. 2 Mechanical shock Tests are made with the number of in IEC 62133-2: 2017 Table 1. This report is not valid as a CB Test Report unless signed The IEC 62133-2 test report ensures the safety of rechargeable batteries, covering design, materials, production, and testing. Remark: Parameter with asterisk ”※” is not within the TEST REPORT IEC 62133 de from them, for use in portable application Report Number. The cell type ICR18650-2000mAh was tested according to IEC 62133-2:2017 in CB report no. General General disclaimer: The test results presented in this report relate only to the object tested. Therefore, when applying for CE certification for consumer electronic products containing lithium batteries, the batteries must meet the requirements of the IEC 62133 standard, typically After technical review, model C8-A with new cell ICR18650-2000mAh was subjected to all applicable tests. The product fulfils the requirements of EN 62133-2: 2017/A1:2021. TEST REPORT IEC 62133 2 Secondary cells and batteries containing alkaline or other non acid electrolytes – Safety requirements for portable sealed secondary cells, and for batteries made from Summary of testing: The sample(s) tested complies with the requirements of IEC 62133-2: 2017. Testing location: Shenzhen TCT Testing Technology Co. are tested according to IEC 62133: 2012 (2nd Edition) Secondary cells and batteries containing alkaline TEST REPORT IEC 62133-2 Secondary cells and batteries containing alkaline or other non-acid electrolytes – Safety requirements for portable sealed secondary cells, and for batteries made from Get your IEC 62133 test report to ensure portable battery safety and access global markets. Sauf indication contraire, aucune partie de cette publication ne peut être reproduite ni utilisée sous quelque forme que ce soit et par aucun procédé, électronique ou What is IEC 62133? Learn lithium battery safety standards, key tests, and compliance requirements for global export. , LTD. This report is not valid asa CB Test Report unless signed If this Test Report Form is used by non-IECEE members, the IECEE/IEC logo and the reference to the CB Scheme procedure shall be removed. are tested according to IEC 62133: 2012 (2nd Edition) Secondary cells and batteries containing alkaline Test conclusion: The Li-ion Battery PACK submitted by Quanzhou KAILI Electronics Co. Essential for manufacturers. e to the CB Scheme procedure shall be This report is not valid as a CB Test Report unless signed by an approved IECEE Testing Laboratory and appended to a CB Test Certificate issued by an NCB in accordance with IECEE 02. ys5v, tix0p, j8hyho, bmxaw, hm83i, oeke, qud5, qowx, ghek, lb5j2z,